COREtec Stone Tile Installation Instructions, Residential Maintenance Guidelines for COREtec Stone Tile, USFloors® Statement of Environmental Responsibility, Additional Videos Showing COREtec® flooring Installation, Tips, and Tricks, 100% Waterproof / 100% Petproof / 100% Kidproof, Features: 100% Waterproof / 100% Petproof / 100% Kidproof. An environmentally safe cork underlayment comes attached to this waterproof flooring makes it extra durable and stable. Subfloor must be flat – 3/16" in 10' or 1/8" in 6'. Learn more. Crawl space clearance from ground to underside of joist is to be no less than 18” and perimeter vent spacing should be equal to 1.5% of the total square footage of the crawl space area to provide cross ventilation. In areas subjected to surface water exposure allow 24 hours for adhesive to cure, reinstall any plumbing fixtures and seal the perimeter of the floor and other vertical surfaces with a waterproof silicone caulk. For the best experience on our site, be sure to turn on Javascript in your browser. All instructions and recommendations should be followed for a satisfactory installation. Recommendations for attaching underlayment panels are not included. Use cementitious patching and leveling compounds that meet or exceed maximum moisture level and pH requirements. Protect the finished flooring from exposure to direct sunlight to reduce fading and thermal expansion. COREtec Stone flooring can be installed over most existing hard–surface floor coverings, provided that the existing floor surface is clean, flat dry and structurally sound. As with many LVT products on the market, COREtec is easy to install and can be done by an experienced... No acclimation needed. Note: Do not cover the entire area of the substrate to prevent damage or present a slip hazard. When cutting inside, dust collection bags should be clean and in place. Step 1: Undercut space under door jamb to allow plank to slide freely. All responsibility for discoloration problems caused by the use of the above mentioned products is not the responsibility of Shaw, but rests with the installer and the underlayment panel manufacture. Subfloor Preparation. Roll underlayment out parallel to the starting wall and allow the poly film to run 2 inches... After the flooring has been installed trim back the poly film from the wall. Product Description. Roll underlayment out parallel to the starting wall and allow the poly film to run 2 inches up the wall. Perfect for both commercial and residential use. Step 9: Use hammer and pull bar to lock long edges of planks on final row. Avoid inhaling wood dust or use a dust mask or other safeguards for personal protection. The embossed thermal-resin top layers are beautifully designed with full color, wood or stone … Use of an in-floor temperature sensor is recommended to avoid overheating. GREENGUARD GOLD Certified®. CoreTec Stone saves you on floor preparation, meaning if your floor is flat then you can install this right now as well as installation costs, again depending on your market most click-together floating flooring installations will cost around $2.50 per square foot. Do not fasten wall moldings and or transition strips to the planks. CAUTION: Some types of nails, such as common steel nails, may cause discoloration of the vinyl floor covering. An additional layer of surface protection provides scratch resistance, and the rigid mineral inner core and cork underlayment lessen the noise of everyday living while providing natural resistance to mold, mildew, and odors. Inspect all planks for damage before installing. COREtec Stone is easier to install … And as part of the COREtec Stone Tile collection, you can be sure it will stand up to your busy lifestyle with minimal care. Learn more. Wood Subfloors
Insert spacer at end of row. Instead, adhere tape to the material used to protect the floor and secure it to the base molding along the wall. Third party testing organizations certify a product's characteristic property to release vapors after installation. Floors shall be smooth, permanently dry, clean, and free all foreign material such as dust, wax, solvents, paint, grease, oils, and old adhesive residue. The embossed thermo-resin layer and integrated grout lines ensure your floors will stay showcase perfect, while you attend to the more important things in life. Stylish, simplified, and strong—COREtec Stone Tile lives like you. If needed add an additional layer of APA rated underlayment, fasten and secure according to the underlayment manufacturer’s recommendations. Tap long edge with hammer and tapping block to lock long edge. Contact the manufacturer of your radiant heating system for further recommendations. COREtec Stone Tile relies on Underwriters Laboratories® (UL) as a third party verifier to test and certify the products' low vapor emission property. Do no install over concrete with a history of high moisture or hydrostatic conditions. Purchase Online or get quote today. Recommended Adhesive(s): Shaw 1500, Shaw 70 (or equivalent/comparable adhesive) using 3/16" x 1/4" x 1/2" V-notched trowel. For best visual effect, shuffle planks or tiles from several cartons and do not install similar planks or tiles next to one another. Installation is NOT allowed over any type of carpet. To minimize shade variation, mix and install planks from several cartons. Maximum operating temperature should never exceed 85°F. COREtec Stone flooring is not recommended directly over fire-retardant treated plywood or preservative treated plywood. If cabinets are to be installed on top of the flooring (including islands), that area of material must be fully adhered to the subfloor (including an additional 2’ beyond the cabinets and islands). DO NOT SAND, DRY SWEEP, DRY SCRAPE, DRILL, SAW, BEADBLAST OR MECHANICALLY CHIP OR PULVERIZE EXISTING RESILIENT FLOORING, BACKING, LINING FELT, ASPHALTIC “CUTBACK” ADHESIVES OR OTHER ADHESIVES. Regardless of new construction or remodeling projects, keep flooring stored in rooms that are not being worked in and only install product after all other trades have completed work that could damage the flooring. Step 2: Lock short end of plank by inserting tongue into groove at an angle and drop in place. COREtec Stone flooring is designed to be installed utilizing the floating method.